高温陶瓷净化生物质气化粗燃气粉尘试验研究

doi:10.16085/j.issn.1000-6613.2016-2374

GIEC OpenIR > 中国科学院广州能源研究所

	高温陶瓷净化生物质气化粗燃气粉尘试验研究
其他题名	An experimental study of dust removal from biomass gasification gas at high temperature by ceramic filter
	谢建军; 郎林; 杨文申; 刘华财; 陈坚; 阴秀丽; 吴创之
	2017-08
发表期刊	化工进展
ISSN	1000-6613
卷号	36 期号:8 页码:2903-2909
摘要	生物质气化得到的粗燃气含有焦油和粉尘杂质,两者形成的混合物在净化装置的高温区易碳化结焦,在低温区容易凝结成团,因此常规的除尘技术并不适用。针对该问题,本文开发了粗燃气高温陶瓷除尘技术,并考察了生物质原料种类、补燃及反吹等工艺条件对除尘室压降和运行温度的影响。试验结果表明：与木片单独气化比较,采用25%成型颗粒燃料+75%木片(质量比)混合气化可导致除尘室阻力上升1200~1500Pa；高温除尘室最佳操作温度为450~550℃,补燃较反吹是降低除尘室压降更有效的手段,当燃气处理量为260~400m3/h时,补燃空气的最佳流量为10~12m3/h,此条件下可使除尘室压降稳定在1200Pa左右。陶瓷管燃气除尘设备可实现100h连续稳定运行,除尘器出口粉尘浓度为10~40mg/m3,粉尘脱除率92.3%~99.8%,焦油脱除率为31.0%~92.5%,且补燃除尘后可燃气体组分浓度基本保持不变。
其他摘要	Hot gas filtration with raw syngas was continuously tested for100hours on a pilot scale purification system,the influence of biomass type,after-burning and back blow on pressure drops and temperatures of dust filter were studied,and the concentrations of gas component,tar and dust in the raw syngas and purified syngas were analyzed.It was found that compared with filtration with syngas from wood chip gasification,the pressure drop of the filter increased by1200-1500Pa while filtration with syngas from co-gasification of pellet(25%mass)and wood chip(75%)the optimal temperature of filter was450-550℃;after-burning with air was a more effective way to decrease the filter pressure drop than back blowing with N2.The optimal flow rate of after-burning air was10-12m3/h when the flow of syngas was260-400m3/h;and the filter pressure drop remained at around1200Pa.It was concluded that the pilot filtration system could continuously and stably run for100hours.The dust content in purified syngas was as low as10-40mg/m3.The dust and tar removal efficiency was92.3%to99.8%and31.0%to92.5%,respectively.The filtration did not reduce the concentration of combustiblegases in purified syngas significantly.
关键词	生物质气化过滤粉尘焦油 biomass gasification filtration dust tar
DOI	10.16085/j.issn.1000-6613.2016-2374
语种	中文
引用统计
文献类型	期刊论文
条目标识符	http://ir.giec.ac.cn/handle/344007/16569
专题	中国科学院广州能源研究所
通讯作者	阴秀丽
作者单位	中国科学院广州能源研究所，中国科学院可再生能源重点实验室，广东省新能源和可再生能源研究开发与应用重点实验室，广东广州510640
第一作者单位	中国科学院广州能源研究所
推荐引用方式 GB/T 7714	谢建军,郎林,杨文申,等. 高温陶瓷净化生物质气化粗燃气粉尘试验研究[J]. 化工进展,2017,36(8):2903-2909.
APA	谢建军.,郎林.,杨文申.,刘华财.,陈坚.,...&吴创之.(2017).高温陶瓷净化生物质气化粗燃气粉尘试验研究.化工进展,36(8),2903-2909.
MLA	谢建军,et al."高温陶瓷净化生物质气化粗燃气粉尘试验研究".化工进展 36.8(2017):2903-2909.

条目包含的文件		下载所有文件
文件名称/大小	文献类型	版本类型	开放类型	使用许可
高温陶瓷净化生物质气化粗燃气粉尘试验研究（1000KB）	期刊论文	出版稿	开放获取	CC BY-NC-SA	浏览下载